Development and Performance Evaluation of a Timer-Controlled Solar- Powered Drip Irrigation System for Smallholder Farmers
DOI:
https://doi.org/10.33003/fjs-2026-1023-6316Abstract
This study developed and evaluated a timer-controlled solar-powered drip irrigation system for smallholder farming. The system used an ESP32 microcontroller and DS3231 real-time clock to schedule irrigation across a 70-day cucumber growth cycle. Hydraulic performance was assessed using coefficient of uniformity (CU), emission uniformity (EU), coefficient of variation (CV) and flow variation (FV). Timer performance was evaluated across four growth stages by comparing actual and programmed irrigation durations. The power subsystem comprised a 50 W PV module, a 10 A/12 V PWM charge controller and a 12 V, 70 Ah lead-acid battery. It was estimated to generate 168.75 Wh/day against an adjusted demand of 100.9 Wh/day, providing about 4.16 days of autonomy at 50% depth of discharge. The pump drew 83.2 W (≈6.93 A at 12 V), and PV output was projected to meet demand at 2.69 peak sun hours/day, below which the battery supplied the deficit. The system achieved CU and EU of 96.74% and 95%, indicating high water-distribution uniformity. CV was 3.96% and FV was 14.63%. Timer errors ranged from −0.94% to +2.68%, with the largest error during the 41-minute mid-season schedule. Analysis of variance showed significant differences in timer error among growth stages (F = 80.86, p < 0.001). These findings demonstrate favourable hydraulic uniformity, timing performance and nominal power-subsystem adequacy. However, crop-yield improvement, water savings and long-term solar reliability were not independently established. Further field evaluation, including solar-energy performance, irrigation-water application and crop response, is recommended before wider deployment
References
REFERENCES
Adeyolanu, D. T., & Okelola, O. E. (2024). Irrigation water management and food security in Nigeria. African Journal of Agriculture and Food Science, 7(4), 117–132. https://doi.org/10.52589/AJAFS-PFPU1QN7
Amaechina, E. C., & Eboh, E. C. (2013). Towards commercialization of irrigated agriculture in Nigeria: Lessons from the Lower Anambra Irrigation Project South-East Nigeria [Conference paper]. Fourth International Conference of the African Association of Agricultural Economists (AAAE), Hammamet, Tunisia. https://doi.org/10.22004/ag.econ.160296
American Society of Agricultural and Biological Engineers. (1999). Field evaluation of microirrigation systems (ASAE Standards EP458). ASABE.
Barroso, F. S. M., Inácio, M. J., & Oliveira, F. G. (2022). Embedded fuzzy controller for application in irrigation systems. Engenharia Agrícola, 42, e20210138. https://doi.org/10.1590/1809-4430-eng.agric.v42nepe20210138/2022
Berdiyeva, D., Otajonov, I., Kiryigitova, S., Sobirova, M., & Sherkuziyeva, G. (2025). Impact of heavy metals (copper, cadmium, mercury, and lead) on the fertility, microbiological activity, and crop productivity of irrigated meadow soils: A literature review from an ecological and food security perspective. Journal of Carcinogenesis, 24(8s), 352–359. https://doi.org/10.64149/J.Carcinog.24.8s.352-359
Bichi, M., & Abdulyakin, M. (2025). Comprehensive analysis of soil physical properties and their relationships: Recommendations for optimized irrigation strategies. CIGR Journal.
Erdem, Y., Arin, L., Erdem, T., Polat, S., Deveci, M., Okursoy, H., & Gültaş, H. T. (2010). Crop water stress index for assessing irrigation scheduling of drip irrigated broccoli (Brassica oleracea L. var. italica). Agricultural Water Management, 98(1), 148–156. https://doi.org/10.1016/j.agwat.2010.08.013
Food and Agriculture Organization of the United Nations. (2022). RuLIS – Rural Livelihoods Information System [Data set]. https://www.fao.org/in-action/rural-livelihoods-dataset-rulis/data-application/data/by-indicator/en
Igbojionu, D. O., Ekejiuba, V. N., Igbojionu, J. N., Ezema, P. C., Sampson, H., & Chiemeka, C. I. (2026). Optimizing irrigation regimes and intervals for improved water productivity and yield of cucumber (Cucumis sativus) in a tropical agroecological zone. FUDMA Journal of Sciences. https://doi.org/10.33003/fjs-2026-1016-3821
International Renewable Energy Agency. (2023). Off-grid renewable energy statistics 2023. https://www.irena.org/publications/2023/Dec/Off-grid-renewable-energy-statistics-2023
Kaunkid, S. (2019). Irrigation control system for drip irrigated tomato in greenhouse using timer-based control method and crop water requirement. Warasan Witthayasat Lae Theknoloyi Mahawitthayalai Mahasarakham, 38(2), 164–172. (No DOI available)
Kim, H. J., Lee, D. H., Ahn, S. W., Kim, W. K., Hur, S. O., Choi, J. Y., & Chung, S. O. (2015). Design and testing of an autonomous irrigation controller for precision water management of greenhouse crops. Engineering in Agriculture, Environment and Food, 8(4), 228–234. https://doi.org/10.1016/j.eaef.2015.03.001
Kuzyakov, Y., Horwath, W. R., Dorodnikov, M., & Blagodatskaya, E. (2019). Review and synthesis of the effects of elevated atmospheric CO2 on soil processes: No changes in pools, but increased fluxes and accelerated cycles. Soil Biology and Biochemistry, 128, 1–14. https://doi.org/10.1016/j.soilbio.2018.10.005
Li, R., Han, Q., Dong, C., Nan, X., Li, H., Sun, H., et al. (2023). Effect and mechanism of micro-nano aeration treatment on a drip irrigation emitter based on groundwater. Agriculture, 13(11), 2059. https://doi.org/10.3390/agriculture13112059
Lozano, D., Ruiz, N., Baeza, R., Contreras, J. I., & Gavilán, P. (2020). Effect of pulse drip irrigation duration on water distribution uniformity. Water, 12(8), 2276. https://doi.org/10.3390/w12082276
Nigerian Meteorological Agency. (2023). 2023 Seasonal Climate Prediction (SCP). http://ngfrepository.org.ng:8080/jspui/handle/123456789/5461
Nurohmah, H., Ali, M., & Priananda, C. W. (2026). RTC-scheduled ESP32 IoT prototype for automated hydroponic nutrient irrigation. Journal of Robotics, Embedded Systems, and Data Analytics, 3(2). https://doi.org/10.66314/joresd.v3i2.694
Okasha, A. (2016). Maximizing irrigation water use efficiency and utilization of solar energy with drip irrigation systems for cucumber production inside greenhouse. Journal of the Advances in Agricultural Researches, 21(3), 454–472.
Olayide, O. E., Tetteh, I. K., & Popoola, L. (2016). Differential impacts of rainfall and irrigation on agricultural production in Nigeria: Any lessons for climate-smart agriculture? Agricultural Water Management, 178, 30–36. https://doi.org/10.1016/j.agwat.2016.08.034
Pavithra, N., Kasara, A. A., Darshini, M., Chethana, G., & Shiny, L. (2018). International Journal of Computer Engineering and Applications, 12, 1–5.
Sewilam, M. R., Elmetwalli, A. M. H., Mohammed, S., & Amer, M. M. (2025). Comparative evaluation of automatic and manual drip irrigation control systems under variable valve opening levels. Journal of Sustainable Agricultural and Environmental Sciences, 4(1), 1–12.
Swanson, C., & Fipps, G. (2009). Evaluation of smart irrigation controllers: Initial bench testing results. Texas Water Resources Institute, Texas A&M University System.
van Opstal, J., & Food and Agriculture Organization of the United Nations. (2021). Guidance on realizing real water savings with crop water productivity interventions: An action framework for agriculture and food security (FAO Water Reports No. 46). FAO. https://katalog.ub.uni-leipzig.de/Record/3-9789251341360
Downloads
Published
Issue
Section
Categories
License
Copyright (c) 2026 Donatus Okwudiri Igbojionu, Valentine Ngozi Ekejiuba, Juliet Nnennaya Igbojionu
This work is licensed under a Creative Commons Attribution 4.0 International License.
