Shrinkage Temperature of Vegetable-Tanned Cow, Goat and Sheep Hides and Skins Previously Exposed to Low-Dose Electron-Beam Irradiation
DOI:
https://doi.org/10.33003/fjs-2026-1021-6333Keywords:
Shrinkage Temperature, Electron-Beam Irradiation, Linear Accelerator, Cow Hide, Goat Skin, Sheep Skin, Collagen, Hydrothermal StabilityAbstract
Shrinkage temperature is a hydrothermal parameter used to assess the response of collagen-containing materials to heating in water. This study reports shrinkage-temperature measurements of cow, goat and sheep hides and skins following nominal low-dose electron-beam irradiation. Eighteen specimens were examined, comprising six pieces from each species. For each species, one specimen was assigned to each of six nominal dose levels: 0, 5, 10, 20, 30 and 50 Gy. Irradiation was performed before vegetable tanning, and each species-dose combination contained only one specimen. Recorded control shrinkage temperatures were 75.7 °C for cow, 74.7 °C for goat and 76.0 °C for sheep. Across the tested doses, cow values ranged from 69.6 °C at 5 Gy to 75.5 °C at 20 Gy; goat values ranged from 69.6 °C at 50 Gy to 74.8 °C at 5 Gy; and sheep values ranged from 73.7 °C at 10 Gy to 75.5 °C at 5 Gy. At 50 Gy, shrinkage-temperature readings were 72.4 °C for cow, 69.6 °C for goat and 74.0 °C for sheep, representing decreases of 3.3, 5.1 and 2.0 °C, respectively, relative to controls. Dose values represent nominal irradiation settings because independent absorbed-dose verification was not documented. Given the single specimen per species-dose combination, findings are descriptive and do not permit estimation of within-group variability or statistical inference. The observed differences alone do not establish radiation-induced changes in collagen stability. These measurements provide preliminary comparative data on shrinkage-temperature readings in tanned leather produced from hides and skins exposed to low nominal electron-beam doses.
References
Akawu, P. I., Onoja, M. A., Musa, Y., Akawu, I., Akintade, S. A., Jakheng, W. E., & Aliyu, U. S. (2023). A comparative study on preservation of animal skin using gamma irradiation as an alternative to salt curing technique. FUDMA Journal of Sciences, 7(3), 193–197. https://doi.org/10.33003/fjs-2023-0703-1744
Akawu, P. I., Onoja, M. A., Garba, N. N., Musa, Y., Akawu, I., Akintade, S. A., & Ojeleye, F. S. (2026). Assessment of dose-dependent effect of linear accelerator electron-beam irradiation on bacterial load of selected animal hides and skins: Implications for preservation. ATBU Journal of Science, Technology and Education, 14(3), 390–395. https://atbufstejoste.com/index.php/joste/article/view/2982
Akawu, P. I., Onoja, M. A., Garba, N. N., Musa, Y., Akawu, I., Bukar, P. H., Akintade, S. A., Jakheng, W. E., Shedow, A., & Mohammed, M. (2026). Comparative assessment of thickness and apparent density in electron-beam-irradiated tanned leather from cow, goat and sheep hides and skins. ATBU Journal of Science, Technology and Education, 14(3), 523–529. https://atbufstejoste.com/index.php/joste/article/view/2996
Apsimon, R., Setiniyaz, S., Seviour, R., Wise, W., Junginger, T., Juarez Hernandez, M., & Ortiz, E. (2021). Initial studies of electron beams as a means of modifying collagen. Physics, 3(2), 220–239. https://doi.org/10.3390/physics3020017
Carsote, C., Șendrea, C., Micu, M.-C., Adams, A., & Badea, E. (2021). Micro-DSC, FTIR-ATR and NMR MOUSE study of the dose-dependent effects of gamma irradiation on vegetable-tanned leather: The influence of leather thermal stability. Radiation Physics and Chemistry, 189, Article 109712. https://doi.org/10.1016/j.radphyschem.2021.109712
Covington, A. D., & Wise, W. R. (2020). Current trends in leather science. Journal of Leather Science and Engineering, 2, Article 28. https://doi.org/10.1186/s42825-020-00041-0
Dąbrowska-Gralak, M., Sadło, J., Głuszewski, W., Łyczko, K., Przybytńiak, G., & Lewandowska, H. (2022). The combined effect of humidity and electron beam irradiation on collagen type I—Implications for collagen-based devices. Materials Today Communications, 31, Article 103255. https://doi.org/10.1016/j.mtcomm.2022.103255
Esteban, B., Baquero, G., Cuadros, R., & Morera, J. M. (2021). Proposal and application of a new method to determine leather shrinkage temperature. Thermochimica Acta, 698, Article 178880. https://doi.org/10.1016/j.tca.2021.178880
Fujii, K. K., Taga, Y., Takagi, Y. K., Masuda, R., Hattori, S., & Koide, T. (2022). The thermal stability of the collagen triple helix is tuned according to the environmental temperature. International Journal of Molecular Sciences, 23(4), Article 2040. https://doi.org/10.3390/ijms23042040
Gaidau, C., Stanculescu, I. R., Stanca, M., Cutrubinis, M., Trandafir, L., Alexandru, M., & Alexe, C.-A. (2021). Gamma irradiation a green alternative for hides and leather conservation. Radiation Physics and Chemistry, 182, Article 109369. https://doi.org/10.1016/j.radphyschem.2021.109369
Huang, X., Zhang, Y., Zheng, X., Yu, G., Dan, N., Dan, W., Li, Z., Chen, Y., & Liu, X. (2022). Origin of critical nature and stability enhancement in collagen matrix based biomaterials: Comprehensive modification technologies. International Journal of Biological Macromolecules, 216, 741–756. https://doi.org/10.1016/j.ijbiomac.2022.07.199
International Atomic Energy Agency. (2000). Absorbed dose determination in external beam radiotherapy: An international code of practice for dosimetry based on standards of absorbed dose to water (Technical Reports Series No. 398). https://pubiaea.org/MTCD/publications/PDF/TRS398_scr.pdf
International Organization for Standardization. (2015). Leather—Physical and mechanical tests—Determination of shrinkage temperature up to 100 °C (ISO Standard No. 3380:2015). https://www.iso.org/standard/61792.html
Khambhaty, Y., & Samidurai, S. (2024). An insight into the microbiome associated with the damage of raw animal hide and skin—Primarily protein, during leather making. International Journal of Biological Macromolecules, 264(Pt. 2), Article 130640. https://doi.org/10.1016/j.ijbiomac.2024.130640
Pawiro, S. A., Mahfirotin, D. A., Assegab, M. I., & Wibowo, W. E. (2022). Modified electron beam output calibration based on IAEA Technical Report Series 398. Journal of Applied Clinical Medical Physics, 23(4), Article e13573. https://doi.org/10.1002/acm2.13573
SATRA Technology. (1997, April). Shrinkage temperature of leather (SATRA TM17:1997). https://www.satra.com/test_methods/detail.php?id=18
Šupová, M., Suchý, T., Chlup, H., Šulc, M., Kotrč, T., Šilingová, L., Žaloudková, M., Rýglová, Š., Braun, M., Chvátil, D., Hrdlička, Z., & Houška, M. (2023). The electron beam irradiation of collagen in the dry and gel states: The effect of the dose and water content from the primary to the quaternary levels. International Journal of Biological Macromolecules, 253, Article 126898. https://doi.org/10.1016/j.ijbiomac.2023.126898
Walker, D. R., Hulgan, S. A. H., Peterson, C. M., Li, I.-C., Gonzalez, K. J., & Hartgerink, J. D. (2021). Predicting the stability of homotrimeric and heterotrimeric collagen helices. Nature Chemistry, 13(3), 260–269. https://doi.org/10.1038/s41557-020-00626-6
Zhang, X., Xu, S., Shen, L., & Li, G. (2020). Factors affecting thermal stability of collagen from the aspects of extraction, processing and modification. Journal of Leather Science and Engineering, 2, Article 19. https://doi.org/10.1186/s4282
Downloads
Published
Issue
Section
Categories
License
Copyright (c) 2026 Patience Akawu, Irimiya Akawu, Sijuwade Akanni Akintade, Mohammed Mohammed, William Emmanuel Jakheng, Alhamdu Shedow, Joshua Obadahun
This work is licensed under a Creative Commons Attribution 4.0 International License.
